混凝土搅拌机定期应该检查的项目!
混凝土搅拌机定期应该检查的项目：
Items that concrete mixer should check regularly:
对卷扬提升制动器进行检查并作适当的调整。
Check and adjust the hoist brake properly.
对水泵，节流阀进行检查，是否有漏水现象。
Check the water pump and throttle valve for water leakage.
对开式齿轮进行检查涂抹润滑油并调整皮带松紧。
Check the open gear, apply lubricating oil and adjust the belt tightness.
检查混凝土搅拌机叶片，衬板的磨损情况，并酌情更换。
Check the abrasion condition of concrete mixer blades and lining plates, and replace them as appropriate.
为了使混凝土搅拌机能够延长其使用寿命，混凝土搅拌机每星期应该检查的项目：
In order to prolong the service life of concrete mixer, the items that concrete mixer should check every week are as follows:
检查混凝土搅拌机钢丝绳磨损情况并在其表明涂少许润滑油，钢丝绳磨损到一定程度后，应进行更换。
Check the wear of steel wire rope of concrete mixer and apply a little lubricating oil on it. After the steel wire rope is worn to a certain extent, it should be replaced.
检查减速箱油面，油泵油量，检查各润滑部位的情况，往料斗滚轮轴承及滑轮轴承加注润滑油。
Check the oil level of the gearbox, the oil quantity of the oil pump, check the condition of each lubricating part, and fill lubricating oil into the hopper roller bearing and pulley bearing.
供水装置要保持清洁，以免堵塞，对吸水阀检查清洗一次。检查行程开关摇臂是否松动，如有松动应予必要调整。
The water supply device should be kept clean to avoid blockage. Check and clean the suction valve once. Check whether the rocker arm of the travel switch is loose, and adjust it if necessary.
检查混凝土搅拌机叶片连接螺栓，支撑臂连接螺栓是否松动酌情调整，叶片与筒壁间的间隙较大间隙5mm并作必要的拧紧。
Check whether the connecting bolts of concrete mixer blades and support arm are loose, adjust them as appropriate, and the gap between blades and cylinder wall is larger, with a gap of 5mm, and tighten them as necessary.
检查混凝土搅拌站电气箱中接触器触头情况。
Check the contact condition of the contactor in the electrical box of the concrete mixing station.
拧开放淤塞，检查轴端密封，作必要的调整修理和更换。
Screw open the blockage, check the shaft end seal, make necessary adjustment, repair and replacement.
感谢您的阅读，希望对您有所帮助，如您还有其他问题想了解，请点击：中科自上料搅拌机https://www.jfjiaobanche.com
Thank you for reading, hope to help you, if you have other questions, please click: Zhongke self feeding mixer https://www.jfjiaobanche.com
下一篇：混凝土搅拌机损坏后的维修?上一篇：搅拌车主机多久清理一次好呢？
