混凝土自上料搅拌车干燥罐定期更新是必然的
混凝土自上料搅拌车干燥罐用来过滤气路系统内压缩空气中水蒸气的，防止储气筒和各类泵阀遭到腐蚀，因此，混凝土自上料搅拌车燥罐能否正常工作，直接影响到性能。其中混凝土自上料搅拌车干燥罐定期更新是必然的，下面来简单讲讲吧。
The drying tank of the concrete self loading mixer truck is used to filter the water vapor in the compressed air in the air circuit system and prevent the air reservoir and various pump valves from being corroded. Therefore, whether the drying tank of the concrete self loading mixer truck can work normally directly affects the performance. Among them, it is inevitable to update the drying tank of concrete self loading mixer truck regularly. Let's talk about it briefly below.
混凝土自上料搅拌车干燥罐虽然不贵，但是很多用户还是能省就省，对干燥罐的品质也无所谓，只要有一个能用就行，有的甚至几年都不换一次。更换干燥罐的操作并不繁琐，利用气罐底部的放气阀门，来查看气罐底部是否潮湿，或者有水。如果干燥罐失效，打开阀门之后会有水流出，应该立即更换新的干燥罐。
Although the drying tank of concrete self loading mixer truck is not expensive, many users can still save, and it doesn't matter about the quality of the drying tank. As long as one can be used, some don't even change it once a few years. The operation of replacing the drying tank is not cumbersome. Use the vent valve at the bottom of the air tank to check whether the bottom of the air tank is wet or there is water. If the drying tank fails, water will flow out after opening the valve, and a new drying tank should be replaced immediately.
好多人都是只要不出问题，几年可能都不会换一次。并且不同品牌的干燥罐使用寿命不一样，而且车辆行驶的气候环境也有差异，更换的周期就很难统一。如果混凝土自上料搅拌车司机们实在不知道何时该更换，可以通过查看储气筒是否有积水的方法来判断。
Many people may not change once in a few years as long as there is no problem. Moreover, the service life of drying cans of different brands is different, and the climatic environment of vehicles is also different, so it is difficult to unify the replacement cycle. If the mixer truck drivers don't know when to replace the concrete, they can judge by checking whether there is water in the air reservoir.
但是在这里也要提醒司机朋友们，因为混凝土自上料搅拌车干燥罐连接着气路，罐体内部与外界有一定的压力差，压缩空气未排空时冒然拆卸，压缩空气瞬间释放，易对拆卸人员造成伤害。
However, it is also necessary to remind the drivers here that since the drying tank of the concrete loading mixer truck is connected with the air circuit, there is a certain pressure difference between the inside of the tank and the outside world. When the compressed air is not emptied, it is disassembled rashly, and the compressed air is released instantly, which is easy to cause harm to the disassemblers.
所以要排空储气筒内空气（反复踩踏刹车，直至气压表读数归零），才可以对干燥罐进行拆卸。借助专用的扳手将干燥罐拆卸下来之后，可以在底座上看到有星星点点的水珠，可见压缩空气的湿度还是很大的。
Therefore, it is necessary to empty the air in the air reservoir (repeatedly press the brake until the barometer reading returns to zero), and then the drying tank can be disassembled. After the drying tank is disassembled with the help of a special wrench, you can see scattered drops of water on the base, which shows that the humidity of the compressed air is still very high.
混凝土自上料搅拌车厂家认为如果干燥罐的过滤效果差的话，这些液态水就会由气路进入到刹车的各个泵阀。在安装新的干燥罐之前要将底座上面清理一下，防止油污进入新罐的内部，影响除湿性能。
The manufacturer of the concrete self loading mixer believes that if the filtering effect of the drying tank is poor, the liquid water will enter into each pump valve of the brake from the gas path. Before installing a new drying tank, clean the base to prevent oil from entering the interior of the new tank and affecting the dehumidification performance.
然后在新干燥罐下面的橡胶垫圈上要涂抹一层机油，起到润滑的作用，防止安装时损坏橡胶垫圈。如果使用劣质产品，或者长时间不更换导致除湿性能丧失,将会严重影响整车的制动。
Then apply a layer of engine oil on the rubber washer under the new drying tank to lubricate and prevent damage to the rubber washer during installation. If inferior products are used, or the dehumidification performance is lost due to long-term non replacement, the braking of the whole vehicle will be seriously affected.
混凝土自上料搅拌车干燥罐定期更新是必然的相关内容就讲解到这里了，所以说对于某些方面还是要真正的在意起来，防止出现问题影响整个工作的进度，更多内容您可以来网站www.jfjiaobanche.com进行咨询。
It is necessary to update the drying tank of the concrete mixer truck regularly since the loading. That's all for the relevant content. Therefore, we should really care about some aspects to prevent problems from affecting the progress of the whole work. For more content, you can consult the website.
