搅拌车各项部件的检查事项
搅拌车制动液面的检查
Inspection of brake fluid level of mixer truck
制动也在高、低位之间则表示正常。如果制动液接近下限或低于下限则表示系统中可能有泄漏或制动蹄片磨损过多,应及时到维修站进行检修。补加制动液时,要注意加同一种型号的制动液,防止损坏皮碗,注意保护好油漆防止腐蚀漆面。
If the braking is also between high and low, it means normal. If the brake fluid is close to or lower than the lower limit, it indicates that there may be leakage in the system or the brake shoe is worn too much, and it should be repaired at the maintenance station in time. When adding brake fluid, pay attention to adding the same type of brake fluid to prevent damage to the leather cup, and pay attention to protect the paint to prevent corrosion of the paint surface.
搅拌车离合器总泵液面的检查
Inspection of liquid level of clutch master cylinder of mixer truck
搅拌车离合器液面介于高、低液面间则表示正常,如果低于标准线,则可能是总泵或分泵皮碗损坏。在发动机运行状态下将出现挂档难或无法挂档的现象,请即时到就近的维修站检修。
If the liquid level of the mixer truck clutch is between high and low, it indicates that it is normal. If it is lower than the standard line, it may be that the master cylinder or the slave cylinder cup is damaged. It will be difficult or impossible to shift when the engine is running. Please go to the nearest maintenance station for maintenance immediately.
搅拌车的蓄电池的保养检查
Maintenance and inspection of mixer battery
检查蓄电池固定是否牢固,电解液应在上限和下限之间,接近下线时应及时补加电解液或蒸馏水至高位线。保持蓄电池正负电缆接触良好,并保持蓄电池清洁干燥。放置时间较长的搅拌车要摘下蓄电池的正负极电缆,相隔半个月左右重新接线起动搅拌车发动机约20分钟后,如果电量明显不足要及时充电。
Check whether the battery is firmly fixed. The electrolyte should be between the upper limit and the lower limit. When it is close to the offline, add electrolyte or distilled water to the high level line in time. Keep the positive and negative cables of the battery in good contact, and keep the battery clean and dry. For the mixer truck that has been placed for a long time, the positive and negative cables of the battery should be removed, and the wires should be reconnected after about half a month. After starting the engine of the mixer truck for about 20 minutes, if the power is obviously insufficient, it should be charged in time.
搅拌车轮胎的检查
Inspection of mixer tires
每月应在常温下检查一下轮胎气压,如果低于正常标准应及时补充轮胎气压。气压不能过高或过低,否则影响驾驶的安全性。检查搅拌车轮胎的龟裂情况,存在安全隐患时应及时更换轮胎。选用轮胎时,应使之型号一致。
Check the tire pressure at normal temperature every month. If it is lower than the normal standard, supplement the tire pressure in time. The air pressure should not be too high or too low, otherwise it will affect the safety of driving. Check the cracking of the mixer truck tires, and replace the tires in time when there are potential safety hazards. When selecting tires, make them the same model.
皮带的检查
Inspection of belt
起动搅拌车发动机或平时驾驶车辆时,皮带发响,全自动搅拌车厂家认为一种情况是皮带长期没有检查调整造成,按正常标准调整即可。另一种情况是皮带老化,需更换。
When starting the mixer engine or driving the vehicle at ordinary times, the belt makes a noise. The manufacturer of the full-automatic mixer believes that one situation is that the belt has not been checked and adjusted for a long time, and it can be adjusted according to the normal standard. The other is that the belt is aging and needs to be replaced.
空气滤清器的检查
Inspection of air filter
空气滤清器过脏会引起搅拌车发动机工作不良、油耗过大,损坏发动机等,检查空气滤清器时,若发现灰尘较少,堵塞较轻,可用高压空气从内向外吹净,继续使用。过脏的空气滤清器应及时更换。九、搅拌车火花塞的检查正常的搅拌车火花塞绝缘陶瓷完好。没有破裂漏电现象,火花塞间隙0.8+-0.0mm放电时,火花呈蓝色,较强。若发现异常需进行调整间隙或更换火花塞。
Dirty air filter will cause poor operation of mixer engine, excessive fuel consumption, engine damage, etc. when checking the air filter, if less dust and light blockage are found, high-pressure air can be used to blow it out from inside to outside and continue to use. The dirty air filter should be replaced in time. 9、 Check the spark plug of the mixer truck. The insulating ceramics of the spark plug of the normal mixer truck are intact. There is no crack and leakage. When the spark plug gap is 0.8+-0.0mm, the spark is blue and strong. If any abnormality is found, adjust the gap or replace the spark plug.
检查搅拌车油滤清器
Check the oil filter of the mixer truck
若发现供油不畅应检查汽油滤清器是否堵塞,如异物堵塞应及时更换。更多相关信息就来网站https://www.jfjiaobanche.com联系我们咨询吧！
If it is found that the fuel supply is not smooth, check whether the gasoline filter is blocked. If it is blocked by foreign matters, replace it in time. Come to the website for more relevant information https://www.jfjiaobanche.com Contact us for advice!
下一篇：自上料搅拌车的弱点要避免掉上一篇：冬季雨雪、结冰天气开搅拌车的技巧须知
