全自动搅拌车厂家讲解雨季如何保养设备
温度渐渐上升，夏天要来了！所以可想而知，雨季要开始了，那么这个时候全自动搅拌车的车主要注意给设备做好雨季保养工作了，不然非常可能会因为进水而造成设备的损坏。下面我们就来讲讲吧。
The temperature is gradually rising, summer is coming! Therefore, it is conceivable that the rainy season is about to begin. At this time, the car of the automatic mixer mainly pays attention to the maintenance of the equipment in the rainy season, otherwise it is very likely to cause damage to the equipment because of the water. Let's talk about it.
由于全自动搅拌车在室外停放的时间比较长，所以在夏雨中直接阵雨的机会较多。然而，今天的雨水中含有越来越多的酸性物质。为防止随车吊的防护漆被雨水侵蚀雨后应立即清洗随车吊，并对设备表面的漆层进行综合保养。
Because the automatic mixer parked in the outdoor for a long time, so in the summer rain direct shower more opportunities. Today, however, rain contains more and more acid. To prevent the protective paint of the truck crane from being eroded by rain, the truck crane should be cleaned immediately after rain, and the paint layer on the surface of the equipment should be comprehensively maintained.
全自动搅拌车内部的电气装置通常容易受到夏雨带来的湿气的影响，造成漏电等小故障，给全自动搅拌车的启动和使用带来不便。因此，建议您在雨天使用专用干燥剂等物质喷洒在电线、火花塞、高压线等易出故障的部位，使其保持干燥。
The electric device inside the automatic mixer is usually susceptible to the influence of moisture brought by summer rain, resulting in small faults such as leakage, which brings inconvenience to the start and use of the automatic mixer. Therefore, it is recommended that you use special desiccant and other substances sprayed in the wire, spark plug, high voltage line and other prone to failure parts, so that it stays dry.
搅拌车出水后检查发动机：检查搅拌车缸内是否有水。进水会导致连杆弯曲，损坏搅拌车发动机。检查搅拌车油中是否有水。油中的水分会使油变质，失去润滑作用，造成搅拌机发动机过度磨损。检查搅拌车变速箱是否有水。齿轮箱内的水会使齿轮箱内的齿轮油变质，造成齿轮磨损。检查搅拌车的刹车油和四轮刹车。刹车油中的水会使刹车油变质，导致刹车失灵。
Check the engine after the water comes out of the mixer truck: first check whether there is water in the cylinder of the mixer truck. Water can cause the connecting rod to bend and damage the mixer engine. Check if there is water in the mixer oil. The moisture in the oil will make the oil deteriorate and lose lubrication, resulting in excessive wear of the mixer engine. Check the mixer gearbox for water. Water in the gear box will make the gear oil in the gear box deteriorate, causing gear wear. Check the mixer's brake oil and four-wheel brakes. Water in the brake oil can deteriorate the brake oil and cause the brakes to fail.
全自动搅拌车厂家认为，如果有水进入排气管，应尽快将积水排掉，以免水中的杂质堵塞三元催化器或损坏氧传感器。检查搅拌车电瓶是否充满水，必要时更换电瓶。对于变速箱车，检查搅拌车变速箱和变速箱控制电脑是否进水。快将浸泡在搅拌机中的物品（座套、脚垫等）擦干，以免发霉。
Automatic mixer truck manufacturers believe that if there is water into the exhaust pipe, the water should be drained as soon as possible, so as not to block the impurities in the water three catalytic converter or damage the oxygen sensor. Check whether the battery of the mixer truck is full of water and replace the battery if necessary. For transmission vehicles, check the mixer transmission and transmission control computer for water. Quickly dry the items (seat covers, floor MATS, etc.) soaked in the blender to avoid mildew.
另外，无论是地面上的积水、污泥还是从空中落下的雨水，其带来的湿气很容易造成全自动搅拌车底盘等金属部件的腐蚀。所以建议大家做好完善的清洁防锈处理。更多内容就来网站www.jfjiaobanche.com咨询吧！
In addition, whether the water on the ground, sludge or rain falling from the air, the moisture is easy to cause corrosion of metal parts such as the chassis of the automatic mixer truck. Therefore, it is recommended that we do a good job of cleaning and rust prevention treatment. More content to the website www.jfjiaobanche.com consultation!
