搅拌车驾驶时要注意许多类难题了
假如驾驶员在搅拌车驾驶时的实际操作不善，就会造成翻车、液压油泵、电机、减速器过快损坏乃出现严重危害。下列全自动搅拌车厂家为大伙儿梳理了一些开搅拌车要留意的难题，期待能帮上大伙儿。
If the driver's actual operation when driving the mixer truck is not good, it will cause rollover, hydraulic oil pump, motor and reducer to be damaged too quickly and even cause serious harm. The following full-automatic mixer truck manufacturers have sorted out some problems that you should pay attention to when driving a mixer truck, and look forward to helping you.
搅拌车运输搅拌好的混凝土时，搅拌筒转速比为2-10转/分，在运送全过程中，平整地面上搅拌筒转速比确保在2-3转/分，行车在侧倾倾斜度超过50的地面，或上下摇晃很大的地面时，应终止搅拌转动，待实时路况转好后再修复搅拌转动。
When the mixer truck transports the mixed concrete, the speed ratio of the mixing drum is 2-10 rpm. During the whole process of transportation, the speed ratio of the mixing drum on the flat ground is ensured to be 2-3 rpm. When the truck is on the ground with a side slope of more than 50 or the ground with a large shaking up and down, the mixing operation shall be stopped, and the mixing operation shall be repaired after the real-time road conditions are improved.
全自动搅拌车运送混凝土的时间不可以超过搅拌站要求的时间。运送混凝土中途，搅拌筒不可长期转停，防止混凝土造成混凝土离析状况。驾驶员应常常观查混凝土状况，出现异常立即通告调度，申请办理作出。
The time for the full-automatic mixer to transport concrete shall not exceed the time required by the mixing station. During the transportation of concrete, the mixing drum shall not be stopped for a long time to prevent concrete segregation caused by concrete. The driver shall often observe and check the concrete condition. In case of any abnormality, the driver shall immediately notify the dispatching center and apply for handling to solve it.
搅拌车车里配有混凝土时，在现场停滞不前时间不可超过1小时，如请求超时应该马上规定当场责任人给与妥善处理。
When the mixer truck is equipped with concrete, the time when the mixer truck stops at the site shall not exceed 1 hour. In case of request for overtime, the person in charge on the site shall be required to handle it properly.
搅拌车运送混凝土混凝土塌落度不可小于8cm。从混凝土入罐到排出来，平均气温高时不可超过2钟头务必排出来，连阴雨天气温度低时，不可超过2.5钟头。
When concrete is transported by mixer truck, the concrete slump shall not be less than 8cm. From the time of concrete pouring into the tank to the time of discharging, the average temperature shall not exceed 2 hours and must be discharged. When the temperature is low in rainy days, the average temperature shall not exceed 2.5 hours.
全自动搅拌车运送混凝土时，汽车转速在1000-1400转/分范畴内工作中，以使柴油发动机有较大扭距，在运送混凝土全过程中，时速不可超过40km/h，以保驾驶。
When the full-automatic mixer truck is transporting concrete, the speed of the truck is within the range of 1000-1400 rpm, so that the diesel engine has a large torque. During the whole process of transporting concrete, the speed shall not exceed 40km / h to ensure safe driving.
全自动搅拌车工作中结束，应把搅拌筒内部和车体清理整洁，不可以使剩下的混凝土留到筒内。
After the work of the full-automatic mixer truck is completed, the interior of the mixer drum and the vehicle body shall be cleaned and tidy, and the remaining concrete shall not be left in the drum.
全自动搅拌车在离心水泵工作中时，严禁高转速，持续应用时不要超过15分钟。
When the full-automatic mixer is working in the centrifugal pump, it is strictly prohibited to rotate at high speed, and the continuous application shall not exceed 15 minutes.
全自动搅拌车储水箱的水流量要常常维持放满，以便急需，冬天关机后，应将储水箱、离心水泵、自来水管、搅拌筒内的水放净，并停到朝阳区、不存水的地区，以防冻裂机械设备。
The water flow of the storage tank of the full-automatic mixer shall be kept full to meet the urgent need. After shutdown in winter, the water in the storage tank, centrifugal water pump, water supply pipe and mixing drum shall be drained and stopped in Chaoyang District and areas without water to prevent the mechanical equipment from cracking.
搅拌车在冬天应立即安装保温套，并应用汽车防冻液对搅拌车多方面维护，依据天气变化更换汽柴油型号，保证机械设备的一切正常应用。
In winter, the mixer truck shall be immediately installed with thermal insulation jacket, and the truck antifreeze shall be used to maintain the mixer truck in various aspects. The gasoline and diesel models shall be changed according to the weather changes to ensure all normal applications of mechanical equipment.
在查验、维修全自动搅拌车液压传动系统一部分时，应以柴油发动机和液压油泵在没有压力的状况下开展。更多注意事项您可来我们网站https://www.jfjiaobanche.com咨询了解！
When inspecting and repairing a part of the hydraulic transmission system of the full-automatic mixer truck, the diesel engine and hydraulic oil pump shall be carried out without pressure. For more information, please visit our website https://www.jfjiaobanche.com Consult and understand!
下一篇：自上料搅拌车置罐体可选材质上一篇：搅拌车上装应该了解的7个小常识
