混凝土自上料搅拌车冬季来临要注意什么？
冬季的到来，温度下降，所以在使用混凝土自上料搅拌车过程中需要多加注意一些事项，那么下面就跟着小编来了解了解吧。
With the arrival of winter, the temperature drops, so in the process of using concrete from the mixing truck need to pay more attention to some matters, then follow the small series to understand it.
混凝土自上料搅拌车开始行走前，所有的操纵杆、踏板和方向盘都应试一次，确保它们处于正常状态后才能开始工作。确保使用适合当地环境的防冻液来冷却发动机。车辆长期不使用时，必须将防冻液排出，防止防冻液结垢。
All the joysticks, pedals and steering wheel should be tested once before the concrete mixing truck starts to run to ensure that they are in normal condition before starting to work. Be sure to use antifreeze suitable for local conditions to cool the engine. When the vehicle is not in use for a long time, antifreeze must be discharged to prevent antifreeze scaling.
控制轮胎充气压力，轮胎气压过高或过低都会导致轮胎过早磨损，严重影响轮胎的使用寿命。检查水泵-风扇传动皮带，皮带长时间使用后，皮带会疲劳变形，降低冷却效果。更换皮带时，要注意型号和长度，正确调整松紧度。
Control tire inflation pressure, tire pressure too high or too low will lead to premature tire wear, seriously affect the service life of tires. Check the pump-fan drive belt, the belt will fatigue deformation after a long time of use, reduce the cooling effect. When replacing the belt, pay attention to the type and length, and adjust the tightness correctly.
清洗混凝土自上料搅拌车柴油箱吸油滤清器；混凝土自上料搅拌车水箱、散热器表面的污染物；更换混凝土自上料搅拌车机油，更换机油和柴油滤清器；更换混凝土自上料搅拌车的变速箱油、油滤；检查搅拌机发动机的气门间隙。
Clean the oil suction filter of the diesel tank of the concrete self-feeding mixer; Remove the pollutants on the surface of water tank and radiator of concrete mixing truck; Replace the oil of the concrete self-feeding mixer, replace the oil and diesel oil filter; Replace the transmission oil and oil filter of the concrete self-feeding mixer; Check valve clearance of mixer engine.
混凝土自上料搅拌车厂家认为在冬季，要经常检查和维护蓄电池的电解液和排气孔。当温度低于-30℃时，电池应采取保温措施，以免冻裂。冬季要注意使用适合当地低温度的燃油、润滑脂、润滑油和液压油（转向系统和驾驶室升降机构用）。
Concrete mixing truck manufacturers think that in winter, to often check and maintain the battery electrolyte and exhaust. When the temperature is below -30℃， the battery should take heat preservation measures to avoid freezing and cracking. In winter, we should pay attention to the use of fuel oil, grease, lubricating oil and hydraulic oil suitable for local low temperature （steering system and cab lifting mechanism）。
根据混凝土自上料搅拌车使用区域的不同，请各位车友做好冬季使用的准备工作。这些准备工作在很大程度上决定了能否、可靠、长久地使用。更多内容的了解就来这里www.jfjiaobanche.com了解吧。
According to the use area of the concrete mixing truck, please prepare for the use in winter. These preparations largely determine whether they can be used safely, reliably and for a long time. For more information, please visit www.jfjiaobanche.com.
