搅拌车空调使用与保养小知识
搅拌车空调使用与保养小知识您知道多少呢？下面就让自上料搅拌车厂家为您讲解一番。
How much do you know about the use and maintenance of mixer air conditioner? Let the self loading mixer manufacturer explain it for you.
一、定期更换搅拌车空调系统软管
1、 Regularly replace the hose of air conditioning system of mixer truck
每一辆配备空调的搅拌车都具有高压管和低压管等若干根由胶管和铝管组成的空调软管，对于新车来说，搅拌车空调软管不易因老化而出现泄漏制冷剂的现象，但是对于超过两年的车来说，高温、腐蚀、振动、撞击等都容易缩短空调软管的使用寿命。
Each air-conditioned mixer truck has several air-conditioning hoses composed of rubber pipes and aluminum pipes, such as high-pressure pipes and low-pressure pipes. For new vehicles, the air-conditioning hoses of the mixer truck are not easy to leak refrigerant due to aging. However, for vehicles more than two years old, high temperature, corrosion, vibration, impact and so on are easy to shorten the service life of the air-conditioning hoses.
因此，检测搅拌车空调系统软管的良好程度尤为重要，对搅拌车空调软管应采取按期强制更换的原则，并定期检查空调系统软管和管接头是否有油迹。如发现渗漏，应及时向汽车维修咨询以及检修更换。
Therefore, it is particularly important to check the good condition of the air-conditioning system hose of the mixer truck. The air-conditioning hose of the mixer truck should be replaced on schedule, and the hose and pipe joint of the air-conditioning system should be checked regularly for oil stains. In case of leakage, consult the automobile maintenance center for maintenance and replacement.
二：多面检查搅拌车空调压缩机部件
2： Inspect the air conditioning compressor components of the mixer truck in multiple ways
搅拌车空调压缩机作为制冷剂流动的动力源在搅拌车空调系统中为重要。检修空调时应注意其前部是否有异响，如有则应先对压缩机进行维修，防止使用一段时间后再修，这样很容易导致冷媒丢失。
As the power source of refrigerant flow, the air-conditioning compressor of mixer truck is very important in the air-conditioning system of mixer truck. When repairing the air conditioner, pay attention to whether there is abnormal noise at the front. If so, repair the compressor first to prevent it from being repaired after a period of use, which may easily lead to the loss of refrigerant.
同时还要检查压缩机皮带是否良好。如果皮带表面与皮带轮槽接触侧面光亮，并且启动搅拌车空调时有明显的噪音，则说明皮带打滑严重，需要更换皮带和皮带轮；如果皮带过松则需要进行调整，否则会使搅拌车空调系统制冷不良。
At the same time, check whether the compressor belt is in good condition. If the surface of the belt and the contact side of the pulley groove are bright, and there is obvious noise when starting the air conditioner of the mixer truck, it means that the belt is seriously slipping, and the belt and pulley need to be replaced; If the belt is too loose, it needs to be adjusted, otherwise the air conditioning system of the mixer truck will have poor refrigeration.
三、注意清理冷凝器表面
3、 Pay attention to cleaning the condenser surface
冷凝器作为搅拌车空调系统的组成部分，往往由于不注意其表面的清理工作，而导致制冷效果下降。所以，在夏季使用空调时可以用水管对着冷凝器进行冲洗，因为搅拌车冷凝器表面的清洁便于使热能散发到外界去。
As a part of the air-conditioning system of the mixer truck, the condenser often fails to pay attention to the cleaning of its surface, resulting in a decline in the cooling effect. Therefore, when the air conditioner is used in summer, water pipes can be used to wash the condenser, because the cleaning of the condenser surface of the mixer truck is easy to dissipate heat energy to the outside.
另外，由于冷凝器安装位置的特殊性，在其迎风一面往往会有许多灰尘、泥土、树叶等异物，日积月累这些异物集覆过多就会导致冷凝器工作效果的降低，所以在维修中应对其表面进行清理，这样可使搅拌车空调系统的制冷效果大大提高。
In addition, due to the particularity of the installation position of the condenser, there are often many foreign matters such as dust, soil, leaves on the windward side of the condenser. If these foreign matters accumulate over time, the working effect of the condenser will be reduced. Therefore, the surface of the condenser should be cleaned during maintenance, which can greatly improve the cooling effect of the air conditioning system of the mixer.
对于这个问题，我们从三个大方面来讲解了，定期对搅拌车进行维护保养具有很好的作用，有更多了解就来我们网站https://www.jfjiaobanche.com咨询吧！
For this problem, we have explained it from three aspects. Regular maintenance of the mixer truck has a good effect. Come to our website for more information https://www.jfjiaobanche.com Consult!
下一篇：介绍一下驾驶搅拌车的注意事项上一篇：搅拌车进行供水操作时要注意什么？
