驾驶混凝土自上料搅拌车要避免的问题
混凝土自上料搅拌车是一种自动上料的搅拌车类型，可以有效节省人力的使用，成为各个建筑厂家所喜爱的一种搅拌车类型，下面混凝土自上料搅拌车厂家带您来看一下驾驶混凝土自上料搅拌车要避免的问题。
The concrete self loading mixer is a type of mixer with automatic loading, which can effectively save manpower and become a favorite type of mixer for various construction manufacturers. The manufacturer of the concrete self loading mixer will show you the problems to avoid when driving the concrete self loading mixer.
一、过度热车
1、 Excessive hot car
不管是冬季还是其它季节，有很多车主都习惯采取原地怠速热车的方式，热车一段时间再行驶，觉得混凝土自上料搅拌车，这时性能佳。但事实上，原地怠速热车不仅效果有限，还浪费汽油和时间。
No matter in winter or other seasons, many car owners are used to idling the hot car in situ. The hot car will drive for a period of time, and they think that the concrete self loading mixer has good performance at this time. But in fact, the hot car idling in place not only has limited effect, but also wastes gasoline and time.
当引擎在没有负荷的状态下，温度的爬升是相当缓慢的，也就是说，引擎在怠速状态下需要很长的时间才能达到正常的工作温度。
When the engine is under no load, the temperature climbs very slowly, that is to say, it takes a long time for the engine to reach its normal operating temperature at idle speed.
正确的做法应当是混凝土自上料搅拌车，原地热车30秒左右后，立即上路行驶。但由于此时引擎及驱动系统都尚未达到正常的工作温度，仍应将转速控制在约2000转/分钟之内，待水温达到正常后方可高转速运行。
The correct method should be that the concrete should be loaded from the mixer truck, and the truck should be warmed up in place for about 30 seconds before driving on the road. However, since the engine and drive system have not reached the normal operating temperature at this time, the speed should still be controlled within about 2000 rpm, and the high speed operation can be started only after the water temperature reaches normal.
二、熄火后仍使用电器设备
2、 Use electrical equipment after flameout
一旦混凝土自上料搅拌车，熄火，蓄电池就处于只放电不充电的工作状态。所以如果在长时间熄火后仍然一直在使用车内大功率用电器，比如开着车辆大灯、停车在路边长时间听音乐等等，这样可能很快导致蓄电池放电、混凝土自上料搅拌车，无法启动的严重后果。
Once the concrete is extinguished from the charging mixer, the battery will be in the working state of only discharging but not charging. Therefore, if the high-power electrical appliances in the vehicle are still used after a long time of flameout, such as driving the headlights, parking at the roadside for a long time to listen to music, etc., this may soon lead to battery discharge, concrete self loading mixer, and serious consequences of failure to start.
三、油箱见底后才加油
3、 Refuel after the fuel tank bottoms out
有人比较懒，有人是很少去注意油箱刻度，直到油箱警示灯亮起后还会再行驶一段距离再去加油。可是有时燃油警示灯亮起后再去找加油站时，有可能出现附近没有加油站的情况，弄得手忙脚乱。而且经常出现这样的情况的话，混凝土自上料搅拌车，的油泵寿命可能会大大降低。
Some people are lazy, and some people seldom pay attention to the fuel tank scale. They will drive a certain distance to refuel until the fuel tank warning light is on. However, sometimes when the fuel warning light lights up and then goes to the gas station, there may be no gas station nearby, causing confusion. In addition, if this happens frequently, the service life of the oil pump of the concrete self loading mixer may be greatly reduced.
但是它的工作并不仅仅局限于混凝土的搅拌工作，还包括混凝土的运输工作，由于车辆的结构比较特殊，在驾驶的过程中是很容易发生一些危险事故的，所以以上就是要避免的问题，希望您认真阅读，关注我们https://www.jfjiaobanche.com带你了解更多事项！
However, its work is not limited to concrete mixing, but also concrete transportation. Due to the special structure of the vehicle, it is easy to cause some dangerous accidents during driving, so the above are the problems to avoid. I hope you can read carefully and pay attention to us https://www.jfjiaobanche.com Learn more!
