混凝土自上料搅拌车进工地时注意观察几点
混凝土搅拌车是“一站三车”的重要组成设备之一，承担着将商品混凝土从搅拌站、可靠、的运输到建设工地的任务。那么混凝土自上料搅拌车进工地时注意观察几点呢？下面混凝土自上料搅拌车厂家为您分析：
Concrete mixer truck is one of the important components of the "one station, three vehicles" equipment, responsible for the safe, reliable, and efficient transportation of commercial concrete from the mixing station to the construction site. So what should be observed when the concrete self loading mixer truck enters the construction site? The manufacturer of the concrete self loading mixer truck will analyze for you:
1、搅拌车进工地时行驶在路中间
1. The mixing truck is driving in the middle of the road when entering the construction site
一般工地道路简易，路基比较松软，靠近路边，容易被压塌方了，导致车辆侧翻。
Generally, the roads on construction sites are simple, and the roadbed is relatively soft. Near the roadside, it is easy to collapse and cause vehicles to roll over.
2、提前下车查看倒车线路
2. Get off the car in advance and check the reversing route
工地一般工况复杂，倒车时下车绕车一周，查看倒车路线，注意躲避障碍物和坑洼，清理遇到的钢筋钉子。
The general working conditions of the construction site are complex. When reversing, get off the car and take a detour around the car. Check the reversing route, pay attention to avoiding obstacles and potholes, and clean up any steel nails encountered.
3、倒车要慢
3. Reverse slowly
别总是把头伸出窗外，要看着两边后视镜一起兼顾，实在不确定就停车看清楚再倒。用一档起步倒车，缓慢而匀速的行驶，好多路面是挖掘机刚刚铺的比较软，车容易陷入。
Don't always stick your head out of the window. Look at both rearview mirrors and consider them together. If you're unsure, stop and look clearly before reversing. Starting from first gear and reversing at a slow and uniform speed, many roads have just been paved with soft excavators, making it easy for the car to get stuck.
4、行车要慢
4. Drive slowly
搅拌车高，高速行驶容易发生事故。入弯之前提前减速减挡，尽量别在拐弯的时候踩刹车。随时注意观察搅拌罐是否在转，把转速尽量调慢，转速过高，车辆产生摆动，出现侧翻。搅拌车在倾斜角大的路段需要停下罐。满载料时走到倾斜角度大的路段，停止罐体的转动可以使车辆行驶的更加平稳。
The center of gravity of the mixer truck is high, and high-speed driving is prone to accidents. Slow down and downshift before entering the corner, and try not to apply the brake when turning. Always pay attention to whether the mixing tank is rotating, and try to slow down the speed as much as possible. If the speed is too high, the vehicle will sway and roll over. The mixing truck needs to stop the tank on a section with a large inclination angle. When fully loaded, walking to a section with a large inclination angle and stopping the rotation of the tank can make the vehicle travel more smoothly.
遇到路面不平，坑坑洼洼地方用合适的低速挡通过，保证车随时有爆发力。注意避让杂物。起步要平稳，不能乱减档，提前减档，保持车辆充足的动力。
When encountering uneven road surfaces or potholes, use a suitable low-speed gear to pass through, ensuring that the car has explosive power at any time. Be careful to avoid debris. Start smoothly, do not downshift randomly, downshift early, and maintain sufficient power of the vehicle.
长时间行驶或者下坡前都要习惯的测试一下刹车。禁止搅拌车空挡滑行下坡，采用低档位发动机减速，下坡路段出现弯路，要在拐弯时提前减速再减挡再减速，带挡刹车效果好。运输前提前规划好路线，注意限高，工地路况复杂，要小心树木，要防止刮到线缆。
Be accustomed to testing the brakes before driving for a long time or downhill. It is prohibited for the mixer truck to slide downhill in neutral. Low gear engines should be used to slow down. If there are bends in the downhill section, it is necessary to slow down in advance and then downshift before decelerating. The braking effect with gear is good. Plan the route in advance before transportation, pay attention to height restrictions, and be careful of the complex road conditions on the construction site. Be careful of trees and prevent scratching the cables.
此外非操作人员，禁止操作。下班后，必须将整车及进料斗、搅拌筒内外、出料溜槽等清洗干净。把车门锁好，转动锁紧手柄，锁牢油门手柄和伺服手柄。更多相关内容就来我们网站https://www.jfjiaobanche.com咨询！
In addition, non operators are prohibited from operating. After work, the entire vehicle, feed hopper, mixing drum, discharge chute, etc. must be cleaned thoroughly. Lock the car, turn the locking handle, lock the throttle handle and servo handle securely. For more related content, come to our website https://www.jfjiaobanche.com consulting service
下一篇：全自动搅拌车的几个使用效果方面描述上一篇：全自动搅拌车厂家如何看好不好？
