自上料搅拌车冬春交替时要注意保暖检查
1。使用自上料搅拌车前，检查水箱、阀门、管道等部件是否结冰。如果发现冰，则先除去冰，然后缓慢启动搅拌机。
1。 Before using the self loading mixer, check whether the water tank, valve, pipeline and other parts are frozen. If ice is found, remove the ice first, and then start the mixer slowly.
2。为避免储气罐内的水在低温下结冰，业主应注意及时排除罐内积水。
2。 In order to prevent the water in the air storage tank from freezing under low temperature, the owner shall pay attention to timely draining the accumulated water in the tank.
3。注意及时更换防冻液。
3。 Pay attention to timely replacement of antifreeze.
4。经常检查和保养蓄电池的电解液和通风口。如果当地温度低于-30℃，则必须将电池取出并放置在室内进行隔热，以避免冻裂。
4。 Regularly check and maintain the electrolyte and vent of the battery. If the local temperature is lower than -30 ℃, the battery must be taken out and placed indoors for thermal insulation to avoid frost cracking.
5。搅拌机发动机启动后，怠速运转约3-5分钟，然后运转搅拌机，直达到正常润滑、正常油压和适当水温。
5。 After the mixer engine is started, run it at idle speed for about 3-5 minutes, and then run the mixer until it reaches normal lubrication, normal oil pressure and appropriate water temperature.
6。搅拌机司机室空调不使用时，为方便系统正常运行，每月启动一次，每次启动10分钟。
6。 When the air conditioner in the mixer cab is not in use, in order to facilitate the normal operation of the system, it shall be started once a month for 10 minutes each time.
7。当施工现场温度低于0℃时，每天使用搅拌车后，必须将水箱和水管内的余水排干，防止水管冻裂。
7。 When the temperature at the construction site is lower than 0 ℃, the remaining water in the water tank and water pipe must be drained after using the mixer every day to prevent the water pipe from cracking.
8。冬季，北方寒冷，南方寒冷，南北温差大。建议是根据施工现场的条件和温度选择符合要求的柴油，并更换相应粘度等级的油。正常情况下，当温度高于0℃时，使用0柴油。一旦温度低于0℃，开始使用负柴油。每10℃为一档，每次温度下降，柴油机车型都需要更换，分别为-10#、-20#、-30#。
8。 In winter, the north is cold, the south is cold, and the temperature difference between the north and the south is large. It is recommended to select diesel oil that meets the requirements according to the conditions and temperature of the construction site, and replace the oil with the corresponding viscosity grade. Under normal conditions, when the temperature is higher than 0 ℃, use 0 diesel oil. Once the temperature is below 0 ℃, start to use negative diesel oil. Every 10 ℃ is the first gear. Every time the temperature drops, the diesel engine models need to be replaced, which are -10\.
9。自上料搅拌车厂家建议要减少洗车次数，洗车时要用温水，洗车后要及时擦拭水渍，否则会结冰。
9。 Since the manufacturer of the charging mixer truck suggested that the number of car washes should be reduced, warm water should be used when washing the car, and the water stains should be wiped in time after washing the car, otherwise it will freeze.
自上料搅拌车冬春交替时要注意保暖检查的相关内容就讲解到这里了，您可以关注我们的网站www.jfjiaobanche.com，获取到更多信息！
This is the end of the explanation about the inspection of keeping warm when the loading mixer truck alternates between winter and spring. You can follow our website www.jfjiaobanche COM, get more information!
