搅拌车的装置驱动使用及操作注意
为了更好的使用设备进行施工，必要的操作注意事项还是要多去了解的，避免问题的存在出现影响我们的正常使用，下面自上料搅拌车厂家就来为您讲讲搅拌车的装置驱动使用及操作注意事项。
In order to better use the equipment for construction, we need to know more about the necessary operating precautions to avoid problems that affect our normal use. Now, the manufacturer of the loading mixer will tell you about the use of the mixer's device drive and the operating precautions.
一旦液压泵发生故障，可按以下紧急驱动步骤进行驱动：
Once the hydraulic pump fails, it can be driven according to the following emergency drive steps:
a、转被好紧急驱动软管（即应急软管）；
a. Turn the emergency drive hose (emergency hose);
b、将故障车（被驱动车）熄火，卸下液压马达上的高压油管接头；
b. Turn off the faulty vehicle (driven vehicle) and remove the high-pressure oil pipe connector on the hydraulic motor;
c、将故障车（驱动车）熄火，将其液压马达的高压油管接头卸下，并与故障车上液压马达的对应接头软管相连接；
c. Turn off the faulty vehicle (drive vehicle), remove the high-pressure oil pipe connector of its hydraulic motor, and connect it with the corresponding connector hose of the hydraulic motor on the faulty vehicle;
d、发动救援车，将其操纵手柄拨出料位置，故障车内的混凝土即被排出；紧急驱动完毕后，将救援软管卸下，并恢复两车原状
d. Start the rescue truck and turn its operating handle to the discharge position, and the concrete in the faulty truck will be discharged; After the emergency drive, remove the rescue hose and restore the two vehicles to their original state
5、操作是注意几个要点
5. Operation is to pay attention to several key points
1、在全自动搅拌车作业前需进行检查，确认转向、制动、灯光、信号系统灵敏有用，搅拌运输车滚筒和溜槽无裂纹和严重损伤，搅拌叶片磨损在正常范围内，底盘和副车架之间的U形螺栓连接良好。
1. Before the operation of the fully automatic mixer truck, it is necessary to check to confirm that the steering, braking, lighting and signal systems are sensitive and useful, the drum and chute of the mixer truck are free of cracks and serious damage, the mixing blades are worn within the normal range, and the U-bolts between the chassis and the subframe are well connected.
2、了解施工要求和现场情况。选择行车路线和停车地点。
2. Understand the construction requirements and site conditions. Select driving routes and parking places.
3、在社会道路上行驶需遵守交通规则。转弯半径应符合使用说明书的要求，时速不大于15km。进站时速不大于5km。
3. Traffic rules must be observed when driving on social roads. The turning radius shall meet the requirements of the user manual, and the speed shall not exceed 15km/h. The speed when entering the station shall not be greater than 5km.
4、作业时，严禁用手触摸旋转的滚筒和滚轮。
4. During operation, it is forbidden to touch the rotating roller and roller with hands.
5、在全自动搅拌车倒车卸料时，需服从指挥，注意周围人员，发现异常立即停车。
5. When backing up the automatic mixer for unloading, obey the command, pay attention to the surrounding personnel, and stop immediately in case of any abnormality.
6、严禁在高压线下进行全自动搅拌车清洗作业。
6. It is strictly prohibited to carry out automatic mixer truck cleaning operation under the high-voltage line.
搅拌车的装置驱动使用及操作注意就讲解到这里了，您对此有什么疑惑或者需求可以随时来我们网站https://www.jfjiaobanche.com进行了解！
This is the end of the note on the use and operation of the mixer drive. If you have any doubts or needs, please visit our website at any time https://www.jfjiaobanche.com Get to know!
